Oil for transfer case Prado 150 4.0. We change the oil in the axles and transfer case. Catalog numbers of consumables
Since the transfer case contains rubbing elements, wear products inevitably appear in it over time. If you do not change the oil in the transfer case in a timely manner, its service life will be reduced. The oil loses performance and fine particles increase gear wear.
How often to change
There are several different types of transfer cases, and depending on the type of mechanism, the frequency of replacement can vary significantly. Typically this information is contained in technical documentation to the car and varies in the range from 50 to 100 thousand kilometers.
In addition, operating conditions affect the service life. The transfer case of a car that drives on public roads experiences much less load than that installed on a car that constantly moves off-road.
How to choose
Two types of fluid are poured into the transfer case: gear oil or ATF fluid. On vehicles with automatic transmission transfer case Usually it is filled with ATF, with a manual transmission - the transmission. In this case, often the liquids must match or be completely compatible.
This is due to the fact that usually the connection between the transfer case and the gearbox is made by a single shaft, or one is attached to the body of the other. When mixing liquids, this will avoid the formation of emulsions, foaming and other side effects.
For most modern cars having a transfer case, the manufacturer recommends using GL-5 class gear oils. They protect hypoid gears well, are designed to operate in the most heavily loaded mechanisms and contain extreme pressure additives.
The viscosity characteristics of oils play an important role. Let's look at the meaning of the numbers using 80W90 oil as an example:
- 80 – viscosity at low temperatures
- W – all-season
- 90 – viscosity at high temperatures
If ATF is used, it is better to fill in the original fluid recommended by the manufacturer, or an analogue that has the appropriate approvals.
What and how much to fill
The table below will allow you to select oil by car brand and find out how much is required.
Automobile | Oil | Volume (l) |
---|---|---|
AUDI | ||
audi q7 (audi q7) | G052162A2, 4014835712317 Ravenol ATF 5/4 HP | 0,85 |
BMW | ||
BMW x5 e53 (bmw x5 e53) | BMW 83 22 9 407 858 "ATF D-III, ATS-500 83220397244 | 1 |
BMW x5 e70 (bmw x5 e70) | 83 22 0 397 244, Multi DCTF, Motylgear 75W80 | 1 |
BMW x3 e83 (bmw x3 e83) | 83229407858 | 1 |
BMW x3 f25 (bmw x3 f25) | BMW Verteilergetriebe 4WD TF 0870 (83 22 0 397 244) | 0,6 |
GAS | ||
gas 66 | TAp-15V, TSp-15K, TSp-Mgip, 80W90 Gl-4 | 1,5 |
GREAT WALL | ||
great wall hover ( Great wall hover) | Dexron III | 1,6 |
JEEP | ||
Jeep Grand Cherokee | Mopar 05016796AC | 2 |
INFINITI | ||
Infiniti fx35 (Infiniti fx35) | Nissan Matic D - KE908-99931 | 2 |
KAMAZ | ||
KAMAZ 43118 | TSp-15K | 5,4 |
KIA | ||
Kia Sorento ( kia sorento) | Dexron II, III (IDEMITSU Multi ATF, GT ATF TYPE Multi Vehicle IV) | 2 |
Kia Sorento 2 (kia sorento 2) | Castrol Syntrax Universal Plus 75W90, RAVENOL TGO 75W90 | 0,6 |
Kia Sportage 1 ( kia sportage 1) | API GL-5 SAE 75W-90 | 1 |
Kia Sportage 2 | 75W90 GL-5 (Mobil Mobilube HD 75W90 GL-5, Castrol 4008177071768 "Syntrax Longlife 75W-90) | 0,8 |
Kia Sportage 3 | HYPOID GEAR OIL API GL-5, SAE 75W/90 | 0,6 |
Kia Sorento TOD | Shell Spirax S4 ATF HDX, MOBIL ATF LT 71141 | 2 |
Kia Sorento Part-Time | ATF Dexron III | 2 |
RANGE ROVER | ||
Land Rover Discovery 3 ( range rover Discovery 3) | SAF-XO 75W-90, Syntrax Longlife 75W-90 | 1,5 |
Land Rover Discovery 4 | Tl7300-Shell Tf0753 | |
Land Rover Freelander 2 | API GL5, SAE 90 | |
Land Rover Defender ( Land Rover Defender) | 75W-140 GL-5 | 2,3 |
LEXUS | ||
Lexus rx300/330 (Lexus rx300/330) | 85W-90, CASTROL TAF-X 75W-90 | 1 |
MERCEDES | ||
Mercedes GLK (Mercedes-Benz GLK-Class) | dispenser in a box | |
Mercedes ml 163 (mercedes ml 163) | 236.13 #A001989230310, Motul Multi ATF | 2 |
Mercedes w163 (Mercedes-Benz w163) | A 001 989 21 03 10 | 1,5 |
Mercedes w164 (Mercedes-Benz w164) | A0019894503 | 0,5 |
MAZDA | ||
mazda cx 5 | GL-5 80W-90, MOBIL Mobilube HD 80w-90 GL-5 | 0,5 |
mazda cx 7 | 80W90 API GL-4/GL-5 | 2 |
MITSUBISHI | ||
Mitsubishi Pajero Sport ( mitsubishi pajero sport) | Castrol TAF-X 75W-90 | 3 |
Mitsubishi Outlander 3, xl ( mitsubishi outlander 3, xl) | 80W90 Gl-5, 75W90 Gl-5 | 0,5 |
mitsubishi l200 (mitsubishi l200) | GL-3 75W-85, GL-4 75W-85 | 2,5 |
Mitsubishi Pajero 2 (mitsubishi pajero 2) | 75W85GL4 | 2,8 |
Mitsubishi Pajero 3 (mitsubishi pajero 3) | GL-5 80W-90, Castrol Syntrans Transaxle 75W-90 | 3 |
Mitsubishi Pajero 4 (mitsubishi pajero 4) | ENEOS GEAR GL-5 75W-90 | 2,8 |
Mitsubishi Montero Sport | Castrol TAF-X 75W-90 | 3 |
Mitsubishi Delica | 75W90 Gl-4 | 1,6 |
NIVA | ||
Niva 2121/21213/21214 (VAZ 2121/21213/21214) | Lukoil TM-5 (75W-90, 80W-90, 85W-90), TNK Trans Gipoid (80W-90), Shell Transaxle Oil (75W-90) | 0,8 |
NISSAN | ||
Nissan x trail t31 (nissan x trail t31) | Nissan Differential Fluid (KE907-99932), Castrol Syntrax universal plus 75w90 GL-4/GL-5 | 0,35 |
Nissan Qashqai | NISSAN Differential Fluid SAE 80W-90 API GL-5 | 0,4 |
Nissan Pathfinder r51 ( Nissan Pathfinder r51) | Nissan Matic-D, Dexron III | 2,6 |
Nissan Terrano | SAE75W90 GL-4, GL-5 | 2 |
Nissan Teana | GL-5 80W90 | 0,38 |
Nissan Murano z51 (Nissan murano z51) | Genuine NISSAN Differential Oil Hypoid SuperGL-5 80W-90 | 0,3 |
OPEL | ||
Opel Antara | GL-5 75W90 | 0,8 |
Opel Mokka | GM 93165693, MOBILUBE 1 SHC 75W-90, Motul GEAR 300 75W-90 | 1 |
PORSCHE | ||
Porsche Cayenne Hang-on | Shell TF0870, RAVENOL Transfer Fluid TF-0870 | 0,9 |
Porsche Cayenne Torsen | Castrol BOT 850, Burmah BOT 850 | 0,9 |
RENAULT | ||
Renault Duster 2.0 4x4 ( renault duster 2.0 4x4) | Elf TransElf Type B 80W90 | 0,75 |
Renault Koleos | Elf TransElf Type B 80W-90, Total Transmission rs fe 80w-90 | 1,5 |
SUZUKI | ||
Suzuki Escudo | SAE 75W-90, 80W-90 API GL-4 | 1,7 |
suzuki grand vitara ( suzuki grand vitara) | 75W-90 API GL-4, SAE 80W-90 API GL-5 | 1,6 |
Suzuki CX4 | TAF-X | 0,6 |
SSANGYONG | ||
SsangYong Kyron (automatic transmission) | Dexron IID, III | 1,3 |
SsangYong Kyron manual transmission | 80W90 API GL-4/GL-5 | 1,4 |
SUBARU | ||
Subaru Forester | no transfer case, reduction gear in the box | |
TOYOTA | ||
Toyota Hilux | API GL3 75W-90 | 1 |
Toyota Land Cruiser Prado 120/150/200 ( Toyota Land Cruiser prado 120/150/200) | GL-5 75W90 Toyota Gear oil | 1,4 |
toyota rav 4 | Toyota Synthetic Gear Oil API GL4/GL5, SAE 75W-90 | |
Toyota Highlander | LT 75W-85 GL-5 TOYOTA | 0,5 |
UAZ | ||
UAZ Patriot | SAE 75W/90 according to API GL-3, TSp-15K, TAP-15V, TAD-17I | 0,7 |
UAZ 469 | TAD-17, 80W90 Gl-5, 85W90 GL-5 | 0,7 |
UAZ Hunter | SAE 75W/90 according to API GL-3 | 0,7 |
URAL | ||
Ural 4320 | TSp-15K | 3,5 |
FORD | ||
Ford explorer 2013 (ford explorer 2013) | Motul 75w140 | 0,4 |
ford kuga ( ford kuga) | SAE 75W-90 | 0,5 |
ford kuga 2 | SAE 75W140 | 0,4 |
Ford Maverick | SAE 75W140 | 2 |
Ford Explorer 5 | SAE 75W140 (Castrol Syntrax Limited Slip 75w140) | 0,4 |
VOLKSWAGEN | ||
Volkswagen Amarok | G052533A2, Castrol Transmax Z | 1,25 |
Volkswagen Touareg | VAG G052515A2, Castrol Transmax Z | 0,85 |
Volkswagen Tiguan | G 052 145 S2 | 1 |
HYUNDAI | ||
Hyundai ix35 (Hyundai ix35) | 75W90 | 1 |
Hyundai Santa Fe 2.7 ( Hyundai Santa Fe 2.7) | Shell Spirax AXME 75W90 | 1 |
Hyundai Tucson | 80W90 GL-4/Gl-5 (Shell Spirax S3 AX 80W-90), 75W90 GL-5 (Сastrol Syntrax Universal 75W-90) | 0,8 |
HONDA | ||
Honda CR-V | transfer case combined with gearbox | |
CHEVROLET | ||
Chevrolet Niva | 80W-90 GL-4, 75W-90 | 0,8 |
Chevrolet Captiva | GL-5 75W90 | 0,8 |
Chevrolet Tahoe | Dexron VI (GM Dexron 6, Spirax S3 ATF MD3, Chevron ATF MD3, AC Delco auto trak II) | 2 |
Chevrolet TrailBlazer | GM Auto-Trak II | 2 |
Check level
On most cars, inspection windows are not provided to check the oil level in the transfer case. Level control and replacement is carried out through the filler hole.
To check, you need to place the car on a flat surface and unscrew the filler bolt, or the control bolt, if any. Usually they are made with a quad or hexagon, or with a wrench.
A normal level is just below the fill/check hole.
The need for replacement is determined by taking a small amount of oil. This can be done using a syringe with a flexible tube attached to the end. Black, cloudy, with traces of wear and tear, must be replaced.
How to change
The replacement procedure itself is simple, but is often complicated by the fact that access to the filler hole is difficult. A lift, inspection pit or overpass is also required.
Some car enthusiasts make their own drain hole in the transfer case to make the procedure as easy as possible complete replacement oils To do this, a hole is drilled at the bottom point for the plug and a thread is cut.
You will need:
- A special syringe for pumping out technical fluids (cost 500-800 rubles). You can use a medical one, but due to its small volume, the replacement process will be significantly delayed. It’s up to you to decide what’s more valuable – time or money.
- Transfer case oil (transmission/ATF) recommended by the manufacturer or having the appropriate specification.
- Gasket sealant, degreasing liquid.
To prevent dirt from getting inside the transfer case, you should clean the surfaces before unscrewing the plugs.
There is a drain hole
If your car is equipped with a drain plug, you need to unscrew the bolt and wait until the oil drains out completely. The magnet on the plug should be cleaned of wear debris. Degrease the drain hole and plug, apply a layer of sealant and screw the plug into place.
Using a syringe, fill the transfer case with oil until it flows over the edge of the filler hole, then screw the plug onto the sealant.
No drain
In this case, all operations are performed through the filler hole. A syringe tube is inserted into it and the oil is pumped out as much as possible. The procedure for filling new oil is no different from that described above.
Land Cruiser Prado 150 - reliable SUV fourth generation from the Japanese automaker Toyota. Since 2012, at the plant in Vladivostok, the car has been equipped with gasoline 1GR-FE (4 l), 2TR-FE, (2.7) l. and a 1KD-FTV turbodiesel engine (3 l). IN in this case We will show you how to change the oil in a 1KD-FTV diesel engine.
When, how much and what kind of oil is needed for Prado 150 (diesel)
In order to choose the right oil for replacement, you must use the instructions included with your car.
If your car is in warranty service, then the use of oils from other manufacturers is not recommended.
For diesel engine 1KD-FTV and its modifications: KDJ150R-GKFEYW, KDJ150R-GKAEYW, KDJ150L-GKFEYW, KDJ150GKAEYW, KDJ155R-GJFEYW, KDJ155R-GJAEYW, KDJ155L-GJFEYW and KDJ155L-GJAEYW, on The best replacement alternative would be the original Toyota Genuine Motor Oil " Also, after the warranty has expired, you can use an equivalent engine oil that meets the API quality and oil viscosity requirements.
For a complete replacement, the following types of oils are suitable: G-DLD-1, API CF-4, CF or ACEA B1; in extreme cases, you can use API CE or CD brands. The recommended oil viscosity must correspond to the temperature conditions climatic conditions operation of the vehicle.
For example, when using oil with a viscosity of SAE 10W-30 or higher at extremely low temperatures, the 1KD-FTV engine may have difficulty starting.
According to the instructions filling volume lubricants will be:
- for replacement with 7.0 l filter;
- for replacement without filter 6.7 l.
Necessary tools and materials for oil change
Tools needed to change the oil:
- wrench 24 mm;
- oil filter puller;
- container for drainage;
- rags;
- new oil filter and oil.
Catalog numbers of consumables:
Original motor Toyota oil Motor Oil (5 l canister) article number - 888080375 will cost about 2,650 rubles. To replace the original, with a saving of 200 rubles, you can get RAVENOL 4014835723559 from the manufacturer - the price of such oil is 2450 rubles. Original oil filter for Toyota engine 9091520003. Price 900 rubles. Analogs: MANN-FILTER W71283 – 240 rubles, BOSCH 451103276 – 110 rubles. The original gasket for the drain bolt is Toyota 90430-22003, priced at 64 rubles.
Prices are indicated for the summer of 2017 for Moscow and the region.
Remove the crankcase cover hatch.
Find the drain plug above it and unscrew it.
Drain the oil into the container provided.
While the oil is draining, we find the filter under the hood and unscrew its cap, this is done using a wrench with an extension.
We take out the filter carefully so as not to spill the oil inside.
Using a compressor with a tube, pump out the remaining oil.
Taking it out of the package new filter and lubricate the rubber band with oil.
Once again I greet all Pradovodov, straight to our cockroaches, the factory manual states that the oil in the axles should be changed every 40 thousand km, well, if it’s necessary, then it’s necessary. At the factory (according to the literature studied), mineral or semi-synthetic oil is poured into the rear and front axles:
Rear axle – 3 liters 85W-90 or 80W-90 (I don’t have LSD),
Front axle - 1.4 liters 85W - 90 or 80W-90.
Since negative temperatures prevail in our region most of the year and on forums they write about a “miraculous” reduction in fuel consumption when operating a car in winter conditions (winter will tell))) due to lower viscosity and lower pour point, it was decided to fill the axles with 75W synthetic -90 and at the same time change the oil in the transfer case (according to the factory manual, 1.4 liters 75W-90). I took 6 liters of TOYOTA Gear Oil Super GL-5 75W-90 oil for the amount of 4255 rubles, 746 rubles per liter. And at 4,000 km (I don’t remember the specific mileage, but it was in early May) I changed it.
Now to the oil change itself, for this you need:
1. 6 liters of oil;
2. A syringe for changing oil in axles or a bottle with a hose that I used (see photo);
3. A set of keys and a 10mm hexagon for unscrewing the drain and filler plug of the front axle;
4. Rags;
5. Inspection hole, of course you can do without it, but it will be inconvenient especially with the front axle.
Changing the oil in the rear axle and transfer case is quite simple, unscrew the drain and filler plugs and pour the oil into a basin, then tighten the drain plug and use a syringe or bottle to fill in new oil to the level of the filler plug. Tighten the cork, pull it through, wipe it.
But I had to beep with the front axle))). First of all, for easy access to the drain plugs of the front axle, remove the metal protection, which is screwed on with 4 bolts. We are trying to unscrew the drain plug of the front axle with a 10 hexagon, but I have this “s.k.uka)))”, despite all my efforts, it never came off, even though I tried to break the plug by placing a half-meter pipe on the hexagon and striking the traffic jam Looking ahead, I found out that this problem with the front axle drain plug that won’t unscrew is quite common on Pradiki. As a result, I had to suck the oil out through the unscrewed filler plug using the above-mentioned bottle with a hose, using it as a vacuum pump. The oil that drained from the bridges was darkish, but from the transfer case it was light. Next, we fill in new oil to the level of the filler plug, tighten the plug, pull it through, wipe it, screw the protection on, smoke, assemble the tool, see how cleverly everything turned out and how nicely time has flown by))) for a useful activity.
Toyota Land Cruiser Prado J150 is the third generation of a frame mid-size SUV. It has been produced in Japan for more than 8 years. During this time, the car received a large number of reviews from drivers. Its advantages include:
- Solid, masculine body design;
- High-quality assembly;
- Durable construction;
- Spacious, comfortable interior;
- Large trunk with built-in power outlet;
- The presence of all-round parking sensors and a rear view camera;
- An appropriate combination of xenon and adaptive head optics.
In addition, the reliability and ease of maintenance of the engines of the latest generation of vehicles were noted. They are presented in two versions: gasoline and diesel. The volume of the first is 2.7 and 4 liters, power is 163 and 282 hp, the second is 3 liters, 173 hp. Installations are combined with a five-speed automatic or manual transmission transmission
A car has not only advantages, but also disadvantages. Weak point What made the SUV different was the paintwork on the body, a narrow and uncomfortable driver's seat and a stiff suspension. Considering the cost of the car is 2.5 million rubles, not every owner can put up with them.
What kind of oil and how many liquids to fill in Toyota Land Cruiser Prado (J150)
Filling/lubrication point |
Filling volume, liters |
Name of oil/liquid |
|||||
Fuel tank | Gasoline engines | 150 | Unleaded motor gasoline with octane number not lower than 95 | ||||
87 | |||||||
Diesel engines | Vehicles with an additional fuel tank | 150 | DT | ||||
Vehicles without additional fuel tank | 87 | ||||||
Engine | 1GR-FE | With filter | 6,1 | 0W-20, 5W-30, 10W-30 Oil type: synthetic |
|||
No filter | 5,7 | ||||||
2TR-FE | With filter | 5,7 | 0W-20, 5W-20, 5W-30 Oil type: synthetic Manufacturer approval: API SL, SM, SN |
||||
No filter | 5,0 | ||||||
1KD-FTV | With filter | 7,0 | 5W-30, 5W-40, 10W-40 Oil type: synthetic Manufacturer approval: API CF-4, CF, CE, CD; ACEA B1 |
||||
No filter | 6,7 | ||||||
Cooling system 1GR-FE | With automatic transmission fluid heater | With rear heater | 12,8 | ||||
Without rear heater | 11,0 | ||||||
Without automatic transmission fluid heater | With rear heater | 12,3 | |||||
Without rear heater | 10,5 | ||||||
Cooling system 2TR-FE | With rear heater | 9,9 | Toyota Super Long Life Coolant | ||||
Without rear heater | 8,1 | ||||||
With manual transmission | With rear heater | 10,1 | |||||
Without rear heater | 8,3 | ||||||
Cooling system 1KD-FTV | With automatic transmission | With rear heater | 14,9 | Toyota Super Long Life Coolant | |||
Without rear heater | 13,1 | ||||||
With manual transmission | With rear heater | 15,0 | |||||
Without rear heater | 13,2 | ||||||
Front differential | 1,4 | Hypoid Gear Oil SX API GL-5 SAE 85W-90 | |||||
Rear differential | 5-door models | With rear differential lock | 2,65 | Hypoid Gear Oil SX API GL-5 SAE 85W-90, Hypoid Gear Oil LSD API GL-5 SAE 85W-90 | |||
Without rear differential lock | 2,70 | ||||||
3-door models | 2,20 | ||||||
Automatic transmission | 1GR-FE | 10,9 | Toyota ATF Type T-IV, Toyota ATF WS | ||||
2TR-FE | 9,9 | ||||||
1KD-FTV | 10,6 | ||||||
Manual transmission | Manual transmission-5 | 2,2 | Gear oil GL-4 or GL-5 class AP with viscosity SAE 75W-90 | ||||
Manual transmission-6 | 2,1 | ||||||
Transfer case | 1,4 | Hypoid Gear oil Super API GL-5 SAE 75W-90 | |||||
Air conditioning system | Front air conditioner | 0,65 | HFC-134a (R134a) | ||||
Front air conditioner + refrigerator | 0,75 | ||||||
Front and rear air conditioning | 0,8 | ||||||
Front and rear air conditioning + refrigerator | 0,9 | ||||||
Steering | 1,0 | Toyota Power Steering Fluid | |||||
P.S.: Dear car enthusiasts, if you have your own information on this topic, please tell us about it in the comments or write an email to the site administration.
Filling volumes and brands of fuel and lubricants liquids Toyota Land Cruiser Prado 150 was last modified: December 31, 2018 by Administrator
Motor oil, replacement volume 7 l. The car can be equipped with a particulate filter (it looks like a 5-10 liter barrel and is located in the place where the catalyst is located in gasoline cars). In this case, the manufacturer recommends JASO DL-1 approval. This is not only low ash content, but also a package of additives aimed at reducing wear of Japanese diesel engines, which are structurally different from European ones.From European recommended motor oils with ACEA C2 approval.If particulate filter no, use oils with API CF/CF-4 approvals. The key to long engine life is frequent oil changes; we recommend 5-7 thousand km.
Automatic transmission oil, full volume 10.6 l . The fluid used is Toyota WS or equivalent. Recommendations for replacement: partially every 30-40 thousand km. On cars with decent mileage, we recommend installing an external oil filter.
Oil in rear axle , volume 2.1 - 2.75 l, only with API classGL-5. Replacement every 20-30 thousand km. All options are presented below.
Front gear oil, volume 1.35 - 1.45 l, only with API classGL-5. The manufacturer is supposed to pour LT 75W-85, this is a regular gear oil, with a slightly reduced high-temperature viscosity.You can cast 75W-90, class GL-5. Replacement every 20-30 thousand km.
Transfer case oil, volume 1.4 l.A VF4BM transfer case is installed, a modified version of the one that was installed on the previous body. The transfer case is controlled electronically by the brain, blocking the center differential. Otherwise, the transfer case has retained the same design. In connection with these changes and the general trend towards a decrease in oil viscosity, Toyota recommends using oil for transfer case. Some owners fill with traditional 75W-90 rated GL-4.Replacement every 40-60 thousand km (every second replacement in the front and rear gearboxes).
Antifreeze, total volume 13.1 - 15 l (with front heater); 15 l (two heaters - front and rear). The manufacturer recommends organic pink antifreeze with an extended lifespan.Recommendations for replacement: the first time after 7-8 years, then once every 3-4 years.
Power steering oil, volume about 1 - 1.5 liters. Or special liquids with the inscription PSF, or automatic transmission fluid
Glow plugs (glow plugs)- 4 pcs
Brake fluid. Look carefully at the inscriptions on the cover expansion tank brake system. If it says "only DOT-3" or "only BF-3", use only Dot-3 fluid. Replacement every two years or every 40 thousand km.
Batteries. The diesel Prado is equipped with 2 batteries of the same size, but with different polarities. Pay attention to this. In the selection, these batteries go one after another.
Headlights. If the low beam is with halogen lamps, then the base is H11, if xenon, then the base is D4S. High beam only halogen lamps, base HB3.